2

Rim Joist Remediation Part 1

Repairing, Protecting, Refinishing the Exterior of the Main Floor Joist Assembly

Part 1: Assessment and Preparation

As we are limited in what we can do in the interior until the asbestos is removed, we have begun tackling the exterior at the main floor rim joist. We were not 100% sure what we would find, but we had several goals:

  • Assess

    Assess the condition of the wall, as well as the assembly components

  • Protect: WRB

    Protect the rim joist assembly and foundation below with a WRB

  • Create Air Barrier

    Create an exterior air barrier to be sealed to the foundation wall and (at minimum) the subfloor (ideally the bottom plate of the stud wall). We will continue the air barrier on the interior wall and seal it to the bottom plate and subfloor

  • Repair & Replace Cladding and Watertable

    Repair and replace the siding where required, and recreate the water table detail at the base of the siding, (this was removed during the flood but can be seen in older photographs)

  • Finish Foundation Wall

    Finish the exterior foundation wall with parging

Assessing the Conditions – Exterior

Before doing anything else we needed to assess the current conditions of the assembly.

We started on the outside. The siding is historically protected, meaning that although we can replace siding that is damaged beyond repair, the goal is to preserve as much of it as possible. This was difficult! The paint had worn off in many areas and rain damage, in combination with its age and the fact that it is so thin at the upper edge, made removing the siding without cracking it at nail penetrations extremely tough.

We used a combination of techniques as required – a variety of crowbars, and the jig (shown) to help us with difficult nails while holding back and protecting the siding. Some was unusable after removal, unfortunately, but much of it was saved. Additionally the boards were often 14 or 16 feet long, often allowing us to salvage at least part of it.

We were excited to find original building paper still relatively intact. Getting under the building paper would require removing 2-3 courses of siding, depending on its condition.

The sheathing was rough cut lumber, approximately 7” in height, and in very good condition. We decided to adhere the air barrier to the bottom course of sheathing, and that the sheathing and bottom plate would be sealed on the inside. The air barrier could be continued on the interior from there (more on this in a future post).

Assessing the Conditions – Interior

We wanted to make sure that the sheathing was in good enough condition to complete this plan, and that the current paper was performing since we intended to lap underneath it. To do this, we cut several interior holes in the wall.

We were pleased that the wood was in excellent condition and showed minimal or no moisture staining. There were some problems at the rear door but this will be addressed after the asbestos abatement.

At the window boxes we found and retrieved what we thought was the time capsule, but turned out to be an old moonshine bottle (at least this is what we are choosing to believe, it was marked XXX Mountain Dew). Gord drank what was left and had a nap for the remainder of the day.

Interior Wall Cavity
Interior Wall Cavity
Drinking the Moonshine

Subfloor Remediation

The subfloor was comprised of 3/4” thick rough cut lumber in varying widths at a 45 degree angle. There were quite a few gaps. Although these aren’t structurally problematic, we were concerned that if mice were using these gaps regularly, they might chew through our brand new air barrier before we had a chance to get it covered. We measured each hole and filled it with plywood, cut at 45 degrees.

Rim Joist Filler
Rim Joist Filler

To Be Continued in Part 2: Rim Joist Air Barrier and WRB

Comments 2

    1. Post
      Author

      Good question! We’ll get into a bit more detail on this in future posts as we discuss parging and how to add exterior stairs to a historically protected building that didn’t historically have stairs (definitely an unusual situation not normally allowed). The building is in the flood fringe – meaning you can rebuild, it just needs to meet the flood fringe building regulations. This all happened several years ago before we got involved in the project, but it was actually moved, a new foundation poured, and then put back. The new foundation is about 2 feet higher than the original and has no openings (no windows etc.).

  1. Your comment is awaiting moderation.

    Incredible many of superb material!
    http://viagrawithoutadoctorsntx.com/
    viagra legal moves generic buy viagra online viagra sales viagra online
    safe online viagra
    viagra multiple myeloma
    is levitra cheaper than viagra
    find sites computer shop viagra
    email virus viagra
    <a href="http://mirabiliatour.blogspot.com/ask?q=+Thanks.+A+lot+of+content.++http%3A%2F%2Fviagrawithoutadoctormsn.com%2F+can+you+take+viagra+and+levitra+buy+viagra+%0D%0Ado+las+vegas+hookers+sell+viagra+%0D%0A%5Burl%3Dhttp%3A%2F%2Fviagrawithoutadoctorsntx.com%2F%5Dviagra+without+a+doctor+prescription%5B%2Furl%5D&submit=ask”>toprol-xl and viagra

  2. Your comment is awaiting moderation.

    Lovely facts. Cheers.
    http://viagrapego.com/
    husband takes viagra viagra without a doctors prescription all about viagra buy generic viagra
    gay viagra
    viagra ingrediants
    kamagra supplier viagra
    cheap viagra walmart
    cheap discount viagra
    <a href="http://mirabiliatour.blogspot.com/ask?q=+Thanks.+A+lot+of+content.++http%3A%2F%2Fviagrawithoutadoctormsn.com%2F+can+you+take+viagra+and+levitra+buy+viagra+%0D%0Ado+las+vegas+hookers+sell+viagra+%0D%0A%5Burl%3Dhttp%3A%2F%2Fviagrawithoutadoctorsntx.com%2F%5Dviagra+without+a+doctor+prescription%5B%2Furl%5D&submit=ask”>cheapest prices for viagra online

  3. Your comment is awaiting moderation.

    Regards, Lots of posts!

    http://viagrapego.com/
    hydrochlorothiazide contradict viagra buy viagra positive test for viagra cheap viagra
    free viagra trial
    coumadin viagra
    satisfaction of calais or viagra
    massage viagra
    <a href="http://mirabiliatour.blogspot.com/ask?q=+Thanks.+A+lot+of+content.++http%3A%2F%2Fviagrawithoutadoctormsn.com%2F+can+you+take+viagra+and+levitra+buy+viagra+%0D%0Ado+las+vegas+hookers+sell+viagra+%0D%0A%5Burl%3Dhttp%3A%2F%2Fviagrawithoutadoctorsntx.com%2F%5Dviagra+without+a+doctor+prescription%5B%2Furl%5D&submit=ask”>viagra how to use
    viagra special delivery uk

  4. Your comment is awaiting moderation.

    You actually mentioned that well!
    http://viagrawithoutadoctorsntx.com/
    take viagra and then penis pump generic viagra 100mg viagra wallpaper generic viagra 100mg
    drugs similiar to viagra
    price on viagra
    viagra russian
    prescription for the real authentic viagra
    <a href="http://www.bryandornan.com/index.php/2010/02/search-engine-optimization-overview/#comments?form2mailerror&inquiry=Business+Development&fname=Howarditala&lname=Howarditala&email=zittel020eejf%40songwriter.net&company=google&phone1=81165293468&phone2=89353854855&phone3=89539955831&comments=+Cheers%21+A+lot+of+data%21++https://nicktambone.com/+mexican+pharmacies+%3Ca+href=%22http://canadianonlinepharmacynnm.com/%22%3Ecanadian+pharmacies-24h%3C/a%3E+cialis+canadian+pharmacy+%3Ca+href=http://canadianpharmaciescubarx.com/%3Ecanada+pharmaceuticals+online%3C/a%3E?form2mailerror&inquiry=Business Development&fname=Brendanlib&lname=Brendanlib&email=stolzenberg334ziz@dutchmail.com&company=google&phone1=86891733399&phone2=88423532441&phone3=83252487268&comments=You actually mentioned this very well! http://viagrawithoutadoctorsntx.com/ viagra 100 pic generic viagra 100mg continuing medil edution lifornia viagra viagra without a doctors prescription“>search viagra pages computer find
    viagra power jamaican comedy

  5. Your comment is awaiting moderation.

    You have made your position very clearly!.
    http://viagrawithoutadoctormsn.com/
    viagra canada deliver cheap viagra generic viagra without a prescription cheap viagra
    viagra usage directions
    what is the best herbal viagra
    viagra shops in atlanta
    toprol-xl and viagra
    <a href="http://mirabiliatour.blogspot.com/ask?q=+Thanks.+A+lot+of+content.++http%3A%2F%2Fviagrawithoutadoctormsn.com%2F+can+you+take+viagra+and+levitra+buy+viagra+%0D%0Ado+las+vegas+hookers+sell+viagra+%0D%0A%5Burl%3Dhttp%3A%2F%2Fviagrawithoutadoctorsntx.com%2F%5Dviagra+without+a+doctor+prescription%5B%2Furl%5D&submit=ask”>viagra mexco
    viagra benefit

Leave a Reply

Your email address will not be published. Required fields are marked *